Product ID:INTERSLEEK 425 FINISH, WHITE, BXA818
MSDS Date:02/20/1998
FSC:8010
NIIN:00N091433
Status Code:A
Kit Part:Y
MSDS Number: CJKNP

COURTAULDS COATINGS INC

6001 ANTOINE DRIVE
HOUSTON, TX 77091
US

Emergency Phone: 800-854-6813

Info Phone: 713-684-1563

Cage: 028S6

INTERNATIONAL PAINT INC

HOUSTON, TX 77091 US

Telephone: 713-684-1244

Cage: 028S6

TITANIUM DIOXIDE

CAS: 13463-67-7

RTECS: XR2275000

OSHA PEL 15 MG/M3

ACGIH TLV: 10 MG/M3

XYLENE; (XYLENE, MIXTURE OF ISOMERS)

CAS: 1330-20-7

RTECS: ZE2100000

OSHA PEL 435 PPM, S

ACGIH TLV: 434 MG/M3;100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

ETHYLBENZENE

CAS: 100-41-4

RTECS: DA0700000

OSHA PEL 435 MG/M3;100 PPM

ACGIH TLV: 434 MG/M3;100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALATION: VAPOR HARMFUL. MAY AFFECT
THE BRAIN OR NERVOUS SYSTEM CAUSING DIZZINESS, HEADACHE OR NAUSEA.
CAUSES NOSE AND THROAT IRRITATION. EYE CONTACT: CAUSES IRRITATION.
SKIN: CAUSES IRRITATION. CAN BE ABSORBED THROUGH SKIN. MAY CAUSE
ORGAN DAMAGE. INGESTION: MAY BE FATAL IF SWALLOWED AND MAY CAUSE
ORGAN DAMAGE. NOTICE: REPORTS HAVE ASSOCIATED REPEATED AND
PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH PERMANENT
BRAIN AND NERVOUS SYSTEM DAMAGE. INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING AND INHALING THE CONTENTS MAY BE HARMFUL OR FATAL.
Explanation of Carcinogenicity:CONTAINS NO INGREDIENTS LISTED AS KNOWN
OR SUSPECTED CARCINOGENS.
Effects of Overexposure:SEE HEALTH HAZARDS.

First Aid:IN ALL CASES OF DOUBT, OR WHEN SYMPTOMS PERSIST, SEEK MED
ATTN. INHAL: REMOVE TO FRESH AIR. IF DISCOMFORT IS PRESENT OR
BREATHING IS ABSENT GET MED ATTN IMMEDIATELY. EYES: FLUSH
IMMEDIATELY W/PLENTY O F WATER FOR AT LEAST 15 MINUTES UNTIL
IRRITATION SUBSIDES. IF IRRITATION PERSISTS, GET MED ATTN. SKIN:
FLUSH W/LARGE AMOUNTS OF WATER. USE SOAP IF AVAILABLE. REMOVE
SEVERELY CONTAMINATED CLOTHING (INC LUDING SHOES) & WASH BEFORE
REUSE. IF IRRITATION PERSISTS, GET MED ATTN. INGESTION: IF
SWALLOWED, DO NOT INDUCE VOMITING. KEEP AT REST. GET PROMPT MED
ATTN. NEVER GIVE ANYTHING BY MOUTH TO UNCONSCIOUS PERSON.

Flash Point:=38.3C, 101.F
Lower Limits:1%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:OSHA CLASSIFICATION: COMBUSTIBLE LIQUID -
CLASS II. ISOLATE FROM HEAT, SPARKS, ELECTRICAL EQUIPMENT & OPEN
FLAME. CLOSED CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.
IN ABSENCE OF ELECTRICITY, WATER SPRAY (FOG NOZZLE IS PREFERRED)
MAY BE USED TO COOL CONTAINERS. DECOMP & COMBUSTION PRODUCTS MAY BE
TOXIC.

Spill Release Procedures:CONTAIN SPILLED LIQUID WITH SAND OR EARTH. DO
NOT USE COMBUSTIBLE MATERIALS SUCH AS SAWDUST. ABSORB SPILL WITH
INERT MATERIAL (E.G., DRY SAND OR EARTH), THEN PLACE IN A CHEMICAL
WASTE CONTAINER.

Handling and Storage Precautions:KEEP CONTAINER CLOSED. LOOSEN CLOSURE
CAUTIOUSLY BEFORE OPENING. STORE IN A COOL, WELL-VENTILATED PLACE
AWAY FROM INCOMPATIBLE MATERIALS (STRONG OXIDIZING AGENTS). KEEP
AWAY FROM HEAT, SPARKS & FLAMES . PROTECT MATERIAL FROM DIRECT
SUNLIGHT.
Other Precautions:GROUND & BOND CONTAINERS WHEN TRANSFERRING MATERIALS.
EMPTY CONTAINERS MAY RETAIN HAZARDOUS PROPERTIES. FOLLOW ALL
MSDS/LABEL WARNINGS, EVEN AFTER CONTAINER IS EMPTIED.

Respiratory Protection:USE A NIOSH APPROVED RESPIRATOR I/A/W 29 CFR
1910.134 TO REMOVE PARTICULATES (AND VAPORS IF THERE IS
OVEREXPOSURE TO VAPORS GENERATED DURING THE PROCESSING OF THIS
PRODUCT.)
Ventilation:PROVIDE SUFFICIENT VENT, IN VOL & PATTERN, TO: A) KEEP TLV
OF HAZ INGS BELOW LIMS SPECIFIED. B) REMOVE VOLATILES PRODUCED
DURING CURE & DECOMP PRODS (SUPP DATA)
Protective Gloves:CHEMICAL RESISTANT GLOVES.
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES & FULL LENGTH
FACESHIELD .
Other Protective Equipment:EYE WASH & DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA . CLOTHING: AS NEEDED, USE BODY PROTECTION TO AVOID
CONTACT WITH PRODUCT.
Supplemental Safety and Health
VENT: PRODUCED DURING WELDING OR CUTTING ON SURFACES COATED WITH THIS
PRODUCT.

Boiling Pt:=137.2C, 279.F
Vapor Density:HVR/AIR
Spec Gravity:1.07
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:WHITE LIQUID.

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:THIS PRODUCT IS STABLE.
Hazardous Decomposition Products:MAY PRODUCE HAZARDOUS FUMES WHEN
HEATED TO DECOMPOSITION AS IN WELDING. FUMES MAY PRODUCE CARBON
DIOXIDE & CARBON MONOXIDE.
Conditions to Avoid Polymerization:HAZARDOUS POLYMERIZATION WILL NOT
OCCUR.

Waste Disposal Methods:DISPOSE OF I/A/W LOCAL, STATE & FEDERAL
REGULATIONS. DO NOT INCINERATE UNOPENED CONTAINERS.

Toxicological Information:THERE IS NO DATA AVAILABLE ON THE PRODUCT
ITSELF. XYLENE: THERE IS A RISK OF ABSORPTION THROUGH SKIN.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:THERE IS NO DATA AVAILABLE ON THE PRODUCT ITSELF.

Transport Information:DOT (DEPARTMENT OF TRANSPORTATION): PROPER
SHIPPING NAME: PAINT. HAZARD CLASS: FLAMMABLE LIQUID, 3. UN NUMBER:
UN1263. PACKING GROUP: PACKING GROUP III.

SARA Title III Information:SARA TITLE III (SUPERFUND AMENDMENTS AND
REAUTHORIZATION ACT): SECTION 302 REPORTABLE INGEDIENTS: NONE
KNOWN. 313 REPORTABLE INGREDIENTS: ETHYLBENZENE - 100-41-4; XYLENE,
MIXTURE OF ISOMERS - 1330-20- 7.
Federal Regulatory Information:WHMIS CLASSIFICATION: CLASS B, DIVISION
3. OSHA REPORTABLE HAZARDOUS COMPONENTS (20 CFR 1910.1200):
TITANIUM DIOXIDE; XYLENE, MIXTURE OF ISOMERS; AND ETHYLBENZENE.
TSCA (TOXIC SUBSTANCE CONTROL ACT): COMPONENTS OF THIS PRODUCT ARE
LISTED ON THE TSCA INVENTORY. CERCLA (COMPREHENSIVE RESPONSE
COMPENSATION, AND LIABILITY ACT): MFR RECOMMENDS YOU CONTACT LOCAL
AUTHORITIES TO DETERMINE IF THERE MAY BE OTHER LOCAL REPORTING
REQUIREMENTS.
State Regulatory Information:CALIFORNIA PROPOSITION 65: WARNING: THIS
PRODUCT CONTAINS A CHEMICAL(S) KNOWN TO THE STATE OF CALIFORNIA TO
CAUSE CANCER, BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM: NONE KNOWN.